AN-94

Topmaul

Active member
Assault rifle innovation isn't only the province of Western gun manufacturers: Behold the AN-94, which features advanced, deadly accurate 2-round burst capabilities, and accepts high-capacity magazines and under-barrel secondary weapon systems.


SoldierTech_AN94-1.jpg


Abakan winner: The AN-94 rifle, a new spin on an old favorite, the AK-74.


Sometimes the easiest way to replace an outdated model is to have a contest -- that's what happened in 1994, when the Russian Army held trials to decide on a new rifle to replace its existing Kalishnikov AK-74 rifle. As with many things in Russia, the trials were confidential, but the story goes they were held in the city of Abakan, which may sound like the title of a Harry Potter novel, but there is nothing kid-like about the innovative assault rifle that won the contest.

Meet the Avtomat Nikonova (or AN, Russian for "Nikonov assault rifle") 94 assault rifle, built by Nikonov (also dubbed the "Abakan," thanks to its victory in the trials), the revolutionary replacement for the AK-74. How revolutionary? How about a "burst mode" just as accurate and deadly as a single-shot mode, a unique cartridge-loading system, and twice the magazine capacity of the older rifle?

Multiple Bursts

It's tough to replace a legend, and sturdy AK-type rifles have proliferated in the past 50 years -- it's estimated that over 90 million have been produced in that time. But in the early 90s it was obviously time for a change, as something more efficient than a 50-year old design was needed for the modern Russian soldier. Adding to the challenge was the fact that the Russians wanted to continue using the same ammunition in the new gun that they used in the AK-74: the 5.45x39mm cartridge, which had the benefit of reduced individual weight, increasing the number of rounds an individual rifleman could carry.

Enter the AN-94, the product of Russia's modernization program. While chambered for the same 5.45x39mm 5N7 cartridge as the AK-74, and vaguely resembling its predecessor (both are built using high impact polycarbonate plastic along the same design lines as the AK-47), take a look inside, and you'll see the AN-94 is a completely different animal.

In order to improve the rifle's lethality, Nikonov took the same approach as did Heckler & Koch in developing the G11 rifle; shoot a multiple round burst as fast as possible before the recoiling parts have time to operate and throw off the trajectory of the fired bullets. To this end, the AN-94 has two distinct rates of fire; 1,800 rounds per minute in the 2-round burst mode, and 600 rounds per minute for fully automatic. However, where H&K eliminated the cartridge case to reduce loading time, Nikonov increased the rate of fire by speeding up the loading process.

In a conventional semi-automatic rifle, to load the next round the bolt must unlock, extract the spent cartridge case, move rearward over the next round to be fed in the magazine, and eject the case. At this point the bolt (driven by the recoil or return spring) is pushed forward, where it strips the next round from the magazine, chambers it, locks in place, and is ready to fire. In the AN-94 this process is sped up through the use of a cable and pulley operated "rammer" which pre-positions the next round in the chamber, eliminating unnecessary reward bolt travel. The rammer functions as follows: as the bolt recoils to the rear the cable (passing through the pulley, pulls the rammer forward, stripping the next round from the magazine and partially chambering it. As the bolt returns forward the rammer resets and the bolt pushes the round completely into the chamber and locks.

SoldierTech_AN94-3.gif


The AN-94's unique rapid reloading system (image from original patent for the rifle): After the first shot is fired, the barrel/receiver is recoiled partially, the first cartridge case is ejected, and the second round is stripped from the magazine.

1. Cartridge in the magazine
2. Cartridge feedway
3. Bolt
4. Barrel assembly, attached to the recoiling receiver
5. Pulley
6. Steel cable links the cartridge rammer to the bolt carrier
7. Cartridge in the feedway, ready to be chambered

Another feature that improves the accuracy of the AN-94 is the blow back shifted pulse recoil system. In a conventional rifle, recoil is absorbed by mechanical means (by springs or weighted buffers) and by the shooter. Shooter absorbed recoil is what causes subsequent shots in fully automatic or conventional burst modes to be less than accurate.

In the AN-94 recoil, in burst mode, is handled in essentially a dual recoiling system. When the first round is fired the entire barrel/bolt assembly begins sliding to the rear, compressing a main recoil spring. In addition the bolt itself is compressing an individual secondary spring, which drives the bolt back forward, whereupon the hammer automatically fires the second round of the burst (all while the barrel is still recoiling reward on the main spring.) Once the second round is fired the bolt locks to the rear until the barrel has recoiled completely and gone back into battery. As soon as the barrel is back in battery the bolt is released and another round is chambered. This arrangement allows for two shots to be fired before any recoiling forces are transferred to the shooter. When fired in the full auto mode the AN-94 first fires a 2 round burst and then goes into fully automatic fire (in which the bolt is held to the rear until the barrel completes its recoiling cycle).

Beyond the 2-round burst capability, the AN-94 is a relatively conventional (by Russian standards) battle rifle. The 94 is capable of mounting a bayonet (though in this case it is mounted to the right of the muzzle rather than below, so as to allow for the use of an under barrel grenade launcher, and horizontally, to enable the user to male side to side slashing attacks while holding the rifle.) and it comes standard with a universal scope mounting rail on the left hand side of the receiver. The AN-94 accepts standard AK-74 30 and 45 round magazines, as well as the new 60 round four-stack magazines. The sights feature a conventional shrouded front sight, which is adjustable for zeroing, and a 5-position rotating aperture rear sight (similar to the German G3) for range.

Put it all together and it adds up to a rifle with 200 meters more range than the AK-74, better accuracy for rapid "burst" firing, and an innovative recoil and reload system, all at a fraction more weight than the standard AK-74. Unfortunately, despite its obvious strengths, the AN-94 will probably not be mass-produced for the Russian army in the foreseeable future. The common reason given for this development is economy -- modern Russia simply doesn't have the rubles for the rifles, especially those that are morecostlyto produce than the standard AK rifle lineup (it is estimated that an AN-94 costs 4-5 times more). However, the AN-94 has gained a reputation as the "professionals' choice," and is still used by Russia's Special Forces and law enforcement agencies. It may be relatively rare (and thus more valuable), but the AN-94 has lived up to the title of Abakan winner.

I have to give credit where credit is due I cut and pasted this form www.warriortalk.com thanks Gabe!
__________________
 
Beautiful weapon right there. One of my favorites. I still prefer to own the AK-74 due to the Avtomat Kalashnikova name. :salute2:
 
Well, AN-94 is some ~15 years old already, and it still is not in wide use in Russian army. Only few elite units is thought to issued this rifle, and only few of those units really uses it in combat (in Chechnya).

It's complicated mechanism is problem as well - it is suitable only for well-trained professionals, not for mass conscript army.

So, imho these factors won't lead to total rearming of army from AKs to ANs... And AN-94 will remain a rare elite weapon for a while more.
 
The Soviets... err.. Russian Forces will not adopt the AN-94. Hell, they still have millions of AK-74s and are currently producing the modernized version of the AKS-74.

It comes down to three things. Money, Gear, and Training. Same reason why the US Department of Defense has not mandated a switch from the AR-15 platform. The Russians have tons of the little bastards in service, they would need to retrain all of their forces for the new rifle, and they only spend money to service and repair the current rifles in service and the new production rifles are simply purchased to replace those that are worn out and cannot be rearsenaled.
 
I've heard bad things about the ergonomics, as well. From what I understand, you cannot easily fire the weapon with the stock folded, and the angle of the pistol grip means that it can be straining on the wrist to fire.
 
i like the AEK-971 much better. It is much simplier, is superior in tests in every category exempt in the 2-shot burst. It uses the good old AK action, but with the balanced recoil of the AK-101 and AK-103, this makes it far easier to transition to it. With it's balanced recoil and very efficent muzzle brake make it 20 to 30% more controllable than the AK-74 which is arguably the most controllable assault rifle on the planet.:2guns:
 
Back
Top